MasterCraft Trailer Instrukcja Użytkownika

Do not tow boat with wakeboards or skis left in board and/orski racks. Doing so may create a hazard for or cause damageto vehicles following behind yo

The Trailer HitchThere are two basic types of trailer hitches: A weight-carryinghitch and a weight-distributing hitch. A weight-carrying hitch isreco

Serious injury or death or property damage canresult if the total weight on your loaded trailerexceeds the capacity of the hitch on your tow vehicle.S

Trailer Winch AssemblyUpon each use of the winch, check for theproper ratchet operation. Do not use the winchif it is damaged. Seek immediate repairs.

MasterCylinder LevelRegularly verify that the brakefluid level comes to the top of the res-ervoir. MasterCraft specificationfor brake fluid is type D

The coupling should not be allowed to lay on the ground where dirtor sand can enter the socket. This can cause excessive wear when thetrailer is towed

• Be sure the white ground wire is properly connected to the trailerframe. Replace any parts that are damaged or badly worn.• A small amount of waterp

As part of the regular maintenance, keep the axle assembly properlylubricated. This procedure is best performed by your MasterCraft dealer.The fill pl

LubricationCurrently, trailers feature oil-bath bearings. Earlier models wereequipped with easy lubricating hubs. However, water invades and seepsthro

Keep your tires properly inflated. Failure to maintainthe correct pressure may result in tire failure andloss of control, which may result in serious

The MasterCraft TrailerCongratulations on your choice of a MasterCraft trailer–the idealmatch for MasterCraft boats. The quality, innovation, selecti

Trailer brakes must be maintained in good workingcondition. The loss of adequate braking could result inserious injury or death or property damage.You

Like any mechanical assembly, a jack requires maintenance tofunction properly over a long period of time. The drive gear and therack-and-pinion should

MasterCraft Trailers • Page 21• Cross the safety cables under the coupling.• Allow only enough slack in the safety cables to handle turns. Whenhitchin

MasterCraft Trailers • Page 22first trip to the lake with your trailer, makeat least one short trial run to familiarizeyourself with its handling char

MasterCraft Trailers • Page 23• Always be courteous. Make it as easy as possible for faster-mov-ing vehicles to pass you. Remain in the slower lane an

weight of the trailer rig and tow vehicle? Is it wide enough? How deepis the water at the end of the ramp?Some launch ramps may be slippery when wet.U

MasterCraft Trailers • Page 25StorageWhen your MasterCraft trailer will not be in use for several months,you can help it continue to give you good per

MasterCraft Trailers • Page 26Trailering Tips• The jack and lug wrench that came with your tow vehicle may alsowork on your trailer, but don’t count o

• Before towing ensurethat the tower on theboat (if so equipped)is secure, whether it isupright and locked inplace or has been low-ered. Also be certa

Limited Warranty Statement(NOTE: The MasterCraft Limited Warranty Statement was written to cover boats and/or trailers.)1. Limited Warranty and Term.

Note: The information given in this manual may not be ap-plicable to international rules of the road. If you have any ques-tions, please contact your

MasterCraft Trailers • Page 29(a) damage caused by misuse, negligence, accident, collision or impact with any object;(b ) damage caused by any imprope

MasterCraft Trailers • Page 30AND TO THE MAXIMUM EXTENT PERMITTED BY APPLICABLE LAW, MASTERCRAFT DISCLAIMS,AND THE OWNER HEREBY EXPRESSLY WAIVES, ANY

Only one (1) transfer under the provisions of this Section 6 (from the original retail purchaserto the second owner), within the applicable time perio

MasterCraft Trailers • Page 32MaintenanceBefore Initial Use:• Read the Owners Manual completely.Before Every Trip:• Verify that the tongue weight and

MasterCraft Trailers • Page 3Warnings and CautionsThroughout this manual the terms “warning” and “caution” ap-pear, alerting the trailer owner or oper

MasterCraft Trailers • Page 4WARNING indicates a potentially hazardous situation which,if not avoided, could result in death or serious injury.1. Befo

7: To reduce the risk of serious injury, death or property dam-age, make certain that all the trailer lights are in properworking order. (Page 14)8: M

MasterCraft Trailers • Page 6Quick TipsHere are some quick tips for maintaining your trailer in tip-top condition:• Chips in the paint, especially on

MasterCraft Trailers • Page 7IntroductionWith the purchase of your new, custom-built MasterCraft traileryou have added value to your MasterCraft boati

The total weight of your boat, engine, fuel, waterand gear must not exceed the trailer’s maximumload-carrying capacity. Overloading can cause seriousi